Automatic WNS Series Industrial Fire Tube Oil Hot Water Boilers

Automatic WNS Series Industrial Fire Tube Oil Hot Water Boilers

Boiler multiple protection: (1) the integration of boiler water level to protect water level and boiler design, the appearance of more compact appearance, accurately show the actual water level in the boiler body function. Coupled with dual independent electronic water level control system to achieve ultra-low water level in the boiler, low water level automatic adjustment function, the normal water level, high water level, ensure that the boiler in a variety of unforeseen circumstances foolproof, secure home. (2) steam pressure protection ☆ pressure controller: selection of high sensitivity of the pressure controller, the pressure is high, or low levels of signal to the electrical switch, other control lines or automatic control chain protection. Common pressure controller and pressure gauge, vapor pressure overpressure alarm can cut off the burner limit is reached; the pressure controller may be single or double fire burning fire the actual operating pressure regulator. ☆ safety valve: safety valve is the last line of defense to protect the boiler, the boiler pressure exceeds the limit, according to the set pressure relief valve design with the school, the exhaust steam pressure relief, to ensure the normal operation of the boiler. (3) having a burner flame protection flame protection inlet means, combustion function is to detect, when the ignition failure or extinguish combustion middle, immediately off the burner into the oil (gas) solenoid valve, the blower continues to operate at this time, the furnace was purged combustible residual gas, after 20 to 30 seconds purge, and various auxiliary blowers automatically cut off power, the boiler operation stops. (4) self-locking power failure protection case, the boiler shutdown immediately burst self-locking power interruption, if the current power is restored, the boiler will not start at any time, you must reset release self-locking, to re-start the ignition.

Efficient heat transfer oil boiler threaded pipe enhanced heat transfer efficiency boiler fuel using the threaded pipe arch tube plate consisting drum, the drum so that a quasi rigid body variant subject elastomeric structure, eliminating the pull tube sheet area support member, reduces stress. Smoke tube consists of two single backhaul backhaul to solve the problem of cracking of the tube plate. A lower drum rise due to the arrangement of the discharge tube, eliminating dead zones at the bottom of the drum, so that there is less deposit sludge, drum high temperature region can be obtained good cooling, preventing the boiler drum package boiler lower case. Efficient heat transfer threaded pipe, the thermal efficiency is obtained heat transfer enhancement effect, to the boiler heating, fast boosting characteristics, improved boiler. Stable, easy adjustment, contribute enough. It has 110% overload capacity. Hot water boilers have been major improvements in the water cycle. Successful use of jet technology, the purpose of the return water jet enters the downcomer, to improve the cycle rate of the riser. Using threaded pipe enhanced heat transfer, the heat transfer coefficient and improve thermal efficiency, since the flue gas has a disturbance in the inner tube, smoke tube hard fouling, plays the role of self-cleaning. Using energy efficient hearth furnace arch integrally cast heat resistant concrete, improved coal fire conditions, it uses a separate plenum, to achieve reasonable air distribution, forming a favorable aerodynamic field of combustion from the chamber, thereby expanding the coal kind of adaptability. Arch furnace boiler, there is a certain part of export smokestacks dust effect. The original boiler control dust emission concentrations below the standard, to ensure that the indicators boiler soot emissions meet the national environmental regulations.

To people a good living environment, the Sichuan Provincial Government to respond positively to the national environmental policy, released the latest notice "Sichuan Province to win the Battle of Blue Sky" and other embodiments of nine. Which highlighted: increase Condensing units and cogeneration units technological transformation efforts, speed up the heating pipe grid design. In areas do not have central heating conditions, the existing multiple small coal-fired boilers, to replace the principle of construction of large-capacity coal-fired boilers in accordance with the same amount. For shutting down key areas of environmental protection, energy consumption, safety and other 300,000 kilowatts coal-fired units of non-compliance.

Scientific and orderly promote clean energy development and utilization of hydropower, natural gas (shale gas), wind power, solar, biomass and so on. As of 2020, the province's hydropower installed capacity reached 79 million kilowatts, the proportion of non-fossil energy consumption reached 37.81%, increase the proportion of natural gas consumption to 16.19%.

The implementation of "Sichuan" Thirteen Five "energy development plan" requirements on coal consumption, increase the intensity of coal washing, coal simultaneous construction of new coal washing facilities, supporting the completion of existing coal mines coal washing facilities in accordance with points Area. Improve coal quality and use of industry standards, do not comply with the provisions of commercial coal quality management and environmental protection requirements of the indicators listed commercial coal. Prohibit the circulation and use of low-grade bulk coal, bulk coal investigated and dealt with according to the law without a license behavior. Increase the civil bulk coal clean governance efforts to promote electricity instead of coal, substitution of gas for coal, to promote the use of clean coal, advanced civilian stoves, strengthen civil bulk coal management. Strengthen regulation and control coal use in autumn and winter. For shutting down key areas of environmental protection, energy, security and other non-compliance of more than 300,000 kilowatts coal-fired units.

What safety matters should be noticed in the operation of industrial boilers?

Industrial boiler is a kind of equipment which must be used by many manufacturing enterprises. It can provide sufficient thermal energy for the production of enterprises so as to ensure that the production can be carried out in an orderly manner. However, because the industrial boiler is dangerous when it is used, the workers who operate it must pay attention to the following items in their daily work in order to better prevent the occurrence of safety accidents. So what safety matters should be noticed in the operation of industrial boilers?

1. Industrial boilers should check the inlet and outlet valves of their gas meters and the main valves in front of the furnace before using them, and close them when the pipes are replaced. When opening the furnace door, we should pay attention to check the situation in the furnace, especially pay attention to the phenomenon of gas leakage, if the leakage is found, it cannot be ignited, but it should be checked and repaired in time to ensure the safety before ignition.

2, pay attention to check the flue of industrial boiler, can't have water or not and keep the flue open all the time. At the same time, no combustible and explosive products such as diesel oil, firecrackers and so on should be placed around the boiler, and safe passageways of sufficient area should be set aside.

3. Start the blower before igniting the industrial boiler and open the air valve on each burner. When igniting, we must pay attention to fire and so on. We must not put the cart before the horse in order to prevent explosion. Also note that the burner should be ignited and adjusted in sequence from top to bottom and from inside to outside.

4. When using industrial boilers, if the blower stops abruptly due to power outages and other reasons, all gas and air valves on the burner should be closed immediately and the furnace doors should be opened if necessary to prevent accidents.

5, the operating room should be equipped with a gas alarm, if found gas leakage of the county should close the indoor gas valve, and then find out the leak point and timely repair, in the course of its attention must not use open fire to detect leakage.

Automatic WNS Series Industrial Fire Tube Oil Hot Water Boilers Related Information

wns series oilgas hot water boiler - rc-modellbau

WNS Series Oil&Gas Fired Hot Water Boil. 2018-10-19 · This series boiler is three-return fire tube hot water boiler. It equip with a bias furnace tube structure, and high temperature gas into the atmosphere through three-return smoke tube, smoke chamber. It equipped with good performance burner and advanced techniques.

Get a Quote

wns series oilgas hot water boiler - rc-modellbau

WNS Series Oil&Gas Fired Hot Water Boil. 2018-10-19 · This series boiler is three-return fire tube hot water boiler. It equip with a bias furnace tube structure, and high temperature gas into the atmosphere through three-return smoke tube, smoke chamber. It equipped with good performance burner and advanced techniques.

Get a Quote

wns hot water boiler - lampa-kunsthandel-galerie.de

wns gas hot water boiler. Steam boiler, electric heating steam boilers, hot water 2018-10-24 · Sitong boiler manufacture and export variety industrial boilers, various fuels can be fired, coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam

Get a Quote

Industrial Wns Series Oilgas Fired Boiler For Industry

wns types boilers_Commercial Boiler_Taniainrome. brand WNS type water treatment steam boilers - krunalent.in. The company's SZS series of fuel (gas) boiler is a typical D-type arrangement of double-drum longitudinal-type water tube boiler, according to the size of the boiler divided into fast-type and assembly type. steam boiler for chemical industry Low nitrogen gas-fired steam boiler for

Get a Quote

Yinchen Brand Wns Series gas oil burner steam boiler

Brand Wns Type Gas Steam Boiler Industrial. Wns Gas And Oil Fired Steam Boiler Simply. Wns Gas And Oil Fired Steam Boiler Simply,Sitong Boiler is a professional manufacturer of industrial oil gas fired boilers in China. the main types is WNS oil gas fired steam boiler and oil gas fired hot water boiler.Alibaba.com offers 3,039 gas thermal oil

Get a Quote

Wns Gas Hot Water Boiler Vs Fire Tube Boiler

Industry Gas Hot Water Fire Tube Boil. WNS Fire Tube Steam Boiler-yuanda-steamboiler.com. The Introduction of WNS Fire Tube Steam Boiler: WNS fire tube steam boiler is a kind of safe and high efficiency heating equipment from Yuanda with full automatic control system, it can also be named as gas/oil steam boiler, packaged boiler, three pass design boiler and eco-friendly boiler.

Get a Quote

Yinchen Brand Wns Series gas oil burner steam boiler

Brand Wns Type Gas Steam Boiler Industrial. Wns Gas And Oil Fired Steam Boiler Simply. Wns Gas And Oil Fired Steam Boiler Simply,Sitong Boiler is a professional manufacturer of industrial oil gas fired boilers in China. the main types is WNS oil gas fired steam boiler and oil gas fired hot water boiler.Alibaba.com offers 3,039 gas thermal oil

Get a Quote

60 Bhp Fire Tube Hot Water Boilers Price

industrial 150 bhp hot water boiler price zg boil. Model CB 15-100 HP Boilers Rev. 07-10 BOILER HP HP. 1 1 1 1.100 Bhp Boiler, 100 Bhp Boiler Suppliers and Industrial Fire Tube 70 100 150 200 250 300 350 400 450 500 550 600 700 Bhp Natural Gas Lpg Diesel Heavy Oil Fired Steam BoilerProduct Finder :: FultonFulton is a global manufacturer of steam, hot water and thermal fluid (hot oil) heat

Get a Quote

wns hot water boiler - lampa-kunsthandel-galerie.de

wns gas hot water boiler. Steam boiler, electric heating steam boilers, hot water 2018-10-24 · Sitong boiler manufacture and export variety industrial boilers, various fuels can be fired, coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam

Get a Quote

fire tube hot water gas boilers - auccurriculumplanner.nl

Hot water boiler / gas / fuel oil / fire tube - HEB series - Babcock Wans. hot water Power source: gas, fuel oil Firebox: fire tube Other characteristics: industrial, low- Indusrial boilers steam boiler / natural gas / fuel oil / fire tube BWB series *Prices are pre-Get a quote

Get a Quote

Wns Series Gas Fired Hot Water Boilers Boilers

WNS gas(oil) fired split hot water boiler manufacturer . 2019-9-6 · Gas(oil) Fired Split Hot Water Boiler. This series of boilers adopts a downstream, three-pass and shell design to ensure that the fuel is fully combusted in a large combustion chamber, and fuel utilization and boiler efficiency are greatly improved.

Get a Quote

WNS Series Gas fired hot water boiler

wns series fuel oil gas fired hot water boiler. WNS Series Oilamp;Gas Fired Hot Water Boiler. 2018-10-19 · This series boiler is three-return fire tube hot water boiler. It equip with a bias furnace tube structure, and high temperature gas into the atmosphere through three-return smoke tube, smoke chamber. Get a quote

Get a Quote

automatic wns oil fired water boiler

Oil/Gas Fired Boiler - Zhong Ding Boiler Co., Lt. CWNS Series Oil/Gas Fired Hot Water Boiler. Zhongding oil gas fired hot water boiler under normal pressure is horizontal three return fire tube hot water boiler It equipped with good performance burner and advanced techniques The burning control, water feed, and program run, etc, are full automatic this boiler is safe and reliable, and also has

Get a Quote

60 Bhp Fire Tube Hot Water Boilers Price

industrial 150 bhp hot water boiler price zg boil. Model CB 15-100 HP Boilers Rev. 07-10 BOILER HP HP. 1 1 1 1.100 Bhp Boiler, 100 Bhp Boiler Suppliers and Industrial Fire Tube 70 100 150 200 250 300 350 400 450 500 550 600 700 Bhp Natural Gas Lpg Diesel Heavy Oil Fired Steam BoilerProduct Finder :: FultonFulton is a global manufacturer of steam, hot water and thermal fluid (hot oil) heat

Get a Quote

Automatic Fire Tube Industrial Oil Gas Boiler For Heating

gas fired steel fire tube type indoor boilers Industria. China 300kw Automatic Fire Tube Diesel Hot Water China 300kw Automatic Fire Tube Diesel Hot Water 500-10000kg/H Fire Tube 3 Pass Wet Back Type Oil Fired Steam Vertical Stainless Steel Coil Tube Structure. Outdoor Gas Boiler, Outdoor Gas Boiler Suppliers [email protected] > Get A Quote >

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top