China 4 Ton 1 25Mpa Pressure Industrial Coal Fired Steam Boiler

China 4 Ton 1 25Mpa Pressure Industrial Coal Fired Steam Boiler

Beiqi Panther car 6 tons of steam condensing one fuel gas china 4 ton 1 25mpa pressure industrial coal fired steam boiler project has been successfully completed. This series boiler adopt advanced design concepts, using the waste heat of flue gas cascade, with the use of the condenser and the economizer fully absorb the waste heat in the flue gas, the boiler efficiency has been greatly improved.

Why horizontal gas china 4 ton 1 25mpa pressure industrial coal fired steam boiler to run under negative pressure? Horizontal Gas-fired steam boilers are generally negative pressure operation, if the pressure is running high temperature flue gas will cause the furnace to burn jet furnace walls and insulation, but also endanger the safety of operating personnel , the negative pressure is not too large, generally -10 ~ -30Pa, small oil-fired boiler is generally because there is no draft fan for the combustion positive pressure. For improving the thermal efficiency of the boiler has the following methods: a low pressure industrial boiler manufacturers has been designed in consideration of the problem of overheating efficiency, device, or change from the flue gas energy aspects is not possible and thus the best energy boiler operation starting from the (here not On the recovered water of vapor condensation). According to statistics survey, the current design of the thermal efficiency of domestic low-voltage industrial boilers is generally 70 to 90%, generally the actual operation of the thermal efficiency of about 60 to 80%, some even below 50%, a small low pressure industrial boilers as long as the operation, maintenance properly, design can achieve the thermal efficiency of the boiler manufacturers. I think the management and operation of the boiler should pay attention to the following points: First, to monitor the boiler exhaust gas temperature. Usually the largest boiler flue gas heat loss is a loss, so control the boiler flue gas temperature is very important, general industrial boilers low pressure gas (mainly refers to less than 10 tons of boiler and pressure of 1.6MPa, the same below) of the exhaust gas temperature is 150 ~ 180 ℃, oil-fired boiler exhaust gas temperature is 210 ~ 240 ℃, when the exhaust gas temperature is too high to find the cause and timely elimination. Causes of high temperature exhaust gas boiler are: a chamber negative pressure is too high, short-circuiting flue gases, the heat pipe 3 soot is too thick, too thick scale pan 4, etc., oil-fired boiler exhaust gas temperature is too high reasons : 1 air not adjusted oil, the oil is not completely burned in the chimney secondary combustion occurs aft, 2 soot too, the need for timely cleaning, the flue gas short circuit 3, 4 is too thick scale, etc. second, the control of boiler blowdown rate. General industrial boiler blowdown rate controlled at 5 to 10%, in the pot of water to ensure that qualified (mainly total alkalinity and pH) under the premise of boiler blowdown rate as low as possible, the sewage to adhere to the "ground row, row less, uniform discharge "principle. Third, the maintenance of good boiler furnace wall insulation. Boiler heat loss is also a relatively large heat losses, now the boiler manufacturers in the manufacturing and design has been well thought out, so we do not need to change, we just trying to be difficult to maintain. Outsourcing surface temperature generally does not exceed the boiler 50 ℃, such as too high will have to find out the reasons, timely elimination. Boiler insulation should always be kept dry for gas boilers, pressure must not run long, or easy to damage the coal furnace wall and gate and so on. Fourth, adjust the ratio of fuel and air volume, complete combustion of the fuel as possible. Small boilers generally do not have the amount of wind testing instruments, we can only go by experience adjustment. For oil-fired boiler, the normal combustion flame was yellow-white, non-glare, flame stability, no visible smoke chimney; for gas boiler, the normal combustion flame as a light yellow, no visible smoke stack, substantially cinder burn coal particles as uniform as possible. Fifth, there must be complete boiler water treatment. Complete boiler water treatment and water quality testing can maximize prevent boiler scaling and correct guidance of the sewage, but it did not do a lot of small boilers, companies usually do not pay attention.

Effect of boiler fine coal combustion boiler operating principle is to use thermal energy or heat in industrial post fuel released by combustion is transferred to the water in the container, the temperature or pressure of the water reaches a certain desired steam heating equipment. Many people will feel that coal-fired boiler more detailed the better, but is it really? From a combustion point of view, the finer coal particles more easily form a good mixing with the air, the more complete the combustion. But the coal particles too small, for boilers, milling power consumption will be greatly increased. Industrial boiler, the coal into the furnace too small, there will be the following questions: 1, coal leakage losses, etc. from grate gap increased. 2, boiler grate to be at full speed, power consumption increases. 3, fly ash, fuel loss increases. 4, a coal burning ember i.e., unstable combustion, furnace volume heat load difficult to sustain stable. So the boiler when using fine particles of coal, coal is subject to how much water, raw coal water, play groups and then into the furnace. If the burning coal of 8 to 12h before the water, so that the penetration of moisture into the interior of the coal particles is better. Water vapor produced is moistened triatomic gases, flue gas can strengthen radiation, facilitate ignition, exhaust and reduce heat loss

Introduce some common sense about the boiler 1, the critical speed of the circulating fluid bed boiler. Gas flow rate corresponding to the minimum fluidization velocity or become known as the critical fluidization velocity. 2, the flow characteristics of circulating bed boiler? A high combustion efficiency of the fuel adaptability 2 3 4 desulfurization efficiency is low nitrogen oxide emissions high combustion intensity 5, 6 simply small cross-sectional area of ​​the furnace fuel and coal pretreatment system 7, a large load adjustment range, adjustment is easy to implement fast ash 8 utilization. 3, the partition circulating fluid bed boiler furnace and the corresponding characteristics into dense and dilute phases, a lower dense phase zone of the furnace, filled with hot materials, is a stable source of hot, heat storage is a thermal store , flow therethrough in an upper dilute phase zone of the furnace, the fuel air are required. 4, the positive balance calculation boiler efficiency, combustion of coal, boiler heat losses What? Coal particles is heated and dried: volatile combustion and precipitation: coal particles swell and rupture: re-cracking and coke burning carbon particles and wear. Heat loss 1 2 3 Chemical incomplete combustion loss of physical mechanical incomplete combustion heat of the loss heat loss 4 5 ash. 5, the charging cycle 4 Effect Effect Effect amount of the main factors affecting combustion in the boiler of a coal particle size distribution and particle 2 was 3 Effect fluidization velocity excess air factor 5 bed temperature Dense Phase 6 . 6, the basic form of the heat transfer in? In the heat transfer process, there are three basic ways of heat transfer: thermal and heat transfer, convective heat and radiant heat transfer. 7, their role in recycling and recycling processes? By the economizer feed water into the steam drum, a descending pipe into the water wall, by absorbing the heat released by the combustion of the fuel heating the water in the saturated steam passes through the heat absorbing further heat saturated steam into dry steam heating. 8, sewage, drainage pipe What? Sewer: blowdown drum door (left and right) turn on the water accident door, front door header sewage, sewage tank after the door, left the door header sewage and right door header sewage, sewage water jacket door (about) Dipleg sewage door. Drainage pipe: the low temperature superheater inlet header hydrophobic doors, front / rear desuperheater hydrophobic door header, the high-temperature superheater inlet / outlet header, the header hydrophobic dispensing door. 9, then what are pipe drum? Meter and accessories? Superheater, economizer recirculation duct, platoon expansion tube, a condenser tube, soot blower tube, economizer inlet pipe, the discharge pipe accident, centralized downcomer platoon expansion, a water level gauge, a thermometer, security door, pressure gauge, gas-water separator, header. 10, the cyclone structure and working principle? Cylindrical body, the central cylinder, a cone, a loop seal, the material returning leg, from the high temperature flue gas out of the furnace, two left and right into the two cyclones, increase after turning flue flue gas velocity in the cylinder the center of rotation of the form cylinder back down into the cone upwardly from the central cylinder wall Shuaixiang excluded smoke particles under high effort when the cone reaches the end coupled with its heavy fall below the loop seal. 11, Refeeder role? The ash from the circulation loop seal into the furnace combustion chamber 12, acting characteristics superheater? The use of flue gas heated to a certain pressure saturated steam superheated steam. 13, bag filter works and composition? Principle: inlet flue gas-containing flue dust particles into the lower caul plate over the flue dust reduction chamber, and then through the outlet to reduce the wind speed of the flue draft fan withdrawn via the discharge plenum chamber clean flue upper portion of the bag filter the atmospheric composition: inlet flue, the caul plate, the reduction of flue gas chamber, bag, net flue gas plenum chamber exit gas, ash silo, rotating ash blowing device, the air reservoir. 14, to the mounting position of the coal feeder, the number, composition mounted on the front wall of the furnace, the number of stage three consists of: a motor, a belt coal feeder, reducer, the motor slide. 15, the process of slag from the furnace down the three tap outlet derived by the discharge of slag, after water cooling to cool to a certain temperature onto the cooling belt-type transfusion Pa, and then transported by the inclined transport slag to the slag bin .

China 4 Ton 1 25Mpa Pressure Industrial Coal Fired Steam Boiler Related Information

1 5 Ton Steam Boiler Made In China -

1 5 Ton Boiler Agent From China - made in china 4 ton coal fired steam boiler for sale. 4 5 ton steam boiler on sale - meubelstichting.nl. boiler as a pioneer in China's boiler industry,can provide many professional types of industrial boiler,such as,gasamp;oil boiler, coal-fired boiler, biomass boiler, thermal fluid heater and other series of more than 400 varieties of specifications. 4 5 ton

Get a Quote

1 25Mpa Steam Boiler - Dorfwirt Hagendorf

1.25mpa industrial gas or oil steam boiler Steam Home Coal Biomass Boilers 1.25mpa industrial gas or oil steam boiler Quick inquiry: I need the quotation of steam boiler hot water boiler, the fuel is, the pressure is, this capacity is, My Name is, my Email is, my phone number is, Please Send the detail information for me!

Get a Quote

1 25mpa biomass boiler - Kamat vihar

1 25mpa biomass boiler - gemamunoz.es. This boiler is a kind of chain grate boiler, which uses coal or biomass as the fuel, it can be called coal fired steam boiler or biomass fired steam boiler. Pressure: 1.0 MPa, 1.25 MPa fuel and gas water tube boiler 20 ton 1.25 Mpa for sale Industrial Coal or Wood Fired 6 Ton 6t/H Steam Boiler. Learn More

Get a Quote

China 1.25MPa Steam Boiler Wood Pellet and Saw

China 1.25MPa Steam Boiler Wood Pellet and Saw Dust Boiler, Find details about China Boiler, China Boiler from 1.25MPa Steam Boiler Wood Pellet and Saw Dust Boiler - Wuxi Zozen Boilers Co., Ltd.

Get a Quote

Coal Fired Steam Boiler

2020-3-14 · 2.Single drum water tube and fire tube boiler. 3.Fuel coal,solid fuel. 4.1 ton 2 ton 4 ton 6 ton coal boiler are package boiler,8 ton 10 ton and bigger capacity are assemble boiler. 5.Working pressure:1.0Mpa 1.25Mpa 1.6Mpa. DZL 2 ton package industrial coal fired steam boiler to Philippines.

Get a Quote

Ton Steam Boiler, China Ton Steam Boiler Suppliers

China Ton Steam Boiler, Ton Steam Boiler from China Supplier - Find Variety Ton Steam Boiler from steam boiler,industrial boiler,power boiler, Boilers Suppliers Located in China, Buy Ton Steam Boiler Made in China on Alibaba.com

Get a Quote

Coal Fired Steam Boiler

2020-3-14 · 2.Single drum water tube and fire tube boiler. 3.Fuel coal,solid fuel. 4.1 ton 2 ton 4 ton 6 ton coal boiler are package boiler,8 ton 10 ton and bigger capacity are assemble boiler. 5.Working pressure:1.0Mpa 1.25Mpa 1.6Mpa. DZL 2 ton package industrial coal fired steam boiler to Philippines.

Get a Quote

Rational Construction Chain Grate Coal Fired Steam

Rational Construction 25 ton Biomass Coal Steam Chain Grate Boilers . Product Description . 1. The boiler adopts the structure of double drum vertical type chain grate, compact structure,beautiful appearance. Assembly delivery,construction the front and rear arch onsite.

Get a Quote

4 Ton Coal Fired Boiler China - cressonniere.be

4 ton 6 ton 8 ton 10 ton coal fired steam boiler. 1 ton to 20 ton coal fired steam boiler,solid fired industrial steam boiler factory. Focous On 1 ton to 20 ton steam boiler [email protected] Call Us +86 150 9345 0119 Home About us Products Coal Fired Boiler Coal Fired . Learn More [email protected] > Get A Quote >

Get a Quote

China 1.25MPa Steam Boiler Wood Pellet and Saw

China 1.25MPa Steam Boiler Wood Pellet and Saw Dust Boiler, Find details about China Boiler, China Boiler from 1.25MPa Steam Boiler Wood Pellet and Saw Dust Boiler - Wuxi Zozen Boilers Co., Ltd.

Get a Quote

4 ton Coal Fired Steam Boiler

3 Pass 4 ton Coal Fired steam boiler. Model DZL4-1.25-AII. Capacity:4 ton steam boiler. Working pressure:1.25Mpa. Features. 1.Sufficient and Steady Capacity,efficiency is more than 82% 2.Chain grate stoker coal fired steam boiler,travelling grate 3.Automatic coal feeding,automatic slag removing. 4.Working pressure :10 bar,13 bar,16bar,25 bar

Get a Quote

1 25Mpa Steam Boiler - Dorfwirt Hagendorf

1.25mpa industrial gas or oil steam boiler Steam Home Coal Biomass Boilers 1.25mpa industrial gas or oil steam boiler Quick inquiry: I need the quotation of steam boiler hot water boiler, the fuel is, the pressure is, this capacity is, My Name is, my Email is, my phone number is, Please Send the detail information for me!

Get a Quote

Coal wood fired 4 ton steam boiler price - DZH4-1.25

2017-11-27 · Coal wood fired 4 ton steam boiler price DZH4-1.25-aii - Yuanda Boiler Products Made In China, China Manufacturer. Capacity:4ton per hour,Contact Nina by email: [email protected] for detailed prices Fuel:coal or wood log Forking pressure:1.25Mpa,181psi Structure:fire tueb and water tube mixed structure,3 pass smoke gas flow. Usage:supply steam for industrial users 1.C orrugated tubes

Get a Quote

grate coal fired steam boiler_ZOZEN BOILER_China

Automatic Feed Fuel Control 1 Ton 1.25MPa Industrial Chain Grate Coal Fired Steam Boiler. Low Pressure. Usage: Industrial. Style: Horizontal. Chat on Line. 100KG/H 0.1T Light Oil Fired Steam Boiler For Cleaning. 10 ton chain grate coal fired steam boiler.

Get a Quote

Coal wood fired 4 ton steam boiler price - DZH4-1.25

2017-11-27 · Coal wood fired 4 ton steam boiler price DZH4-1.25-aii - Yuanda Boiler Products Made In China, China Manufacturer. Capacity:4ton per hour,Contact Nina by email: [email protected] for detailed prices Fuel:coal or wood log Forking pressure:1.25Mpa,181psi Structure:fire tueb and water tube mixed structure,3 pass smoke gas flow. Usage:supply steam for industrial users 1.C orrugated tubes

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top